Opel Astra A

1991-1998 of release

Repair and operation of the car



Opel Astra A
+ 1. Maintenance instruction
- 2. Maintenance
   2.1. Technical characteristics
   - 2.2. Maintenance operations
      2.2.1. Introduction
      2.2.2. Current maintenance
      - 2.2.3. Maintenance through 15 000 km or each 12 months
         2.2.3.1. Engine oil and oil filter
         2.2.3.2. Check of hoses and connections on existence of leaks
         2.2.3.3. Check of steering and suspension bracket
         2.2.3.4. Check of boots of half shafts
         2.2.3.5. Check of level of liquid of the automatic transmission
         2.2.3.6. Survey and cleaning of a radiator
         2.2.3.7. Speed of idling and composition of fuel mix
         2.2.3.8. Check of system of production of the fulfilled gases
         2.2.3.9. Conducting check
         2.2.3.10. Ignition advancing corner
         2.2.3.11. Replacement of brake fluid
         2.2.3.12. Check of brake slips
         2.2.3.13. Check of the connecting mechanism of the emergency brake
         2.2.3.14. Valve check of restriction of pressure in a contour of back brakes
         2.2.3.15. Check of level of hydraulic liquid
         2.2.3.16. Check of system of adjustment of height of a back suspension bracket
         2.2.3.17. Check of a condition of a body
         2.2.3.18. Check of loops and locks
         2.2.3.19. Check of a maple belt of the generator
         2.2.3.20. Adjustment of headlights of head light
         2.2.3.21. Replacement of the filter
         2.2.3.22. Battery of a door key
         2.2.3.23. Check of the car in road conditions
      + 2.2.4. Maintenance each 30 000 km or in 24 months
      + 2.2.5. Maintenance each 60 000 km or in 48 months
+ 3. Engines
+ 4. Ventilation and heating
+ 5. Power supply system
+ 6. System of decrease in toxicity
+ 7. Coupling
+ 8. Transmissions
+ 9. Half shafts
+ 10. Brake system
+ 11. Suspension bracket and steering
+ 12. Body
+ 13. Electric equipment
+ 14. Electrical circuitries


0a910c3c




2.2.3. Maintenance through 15 000 km or each 12 months

GENERAL INFORMATION

Arrangement of elements in a motive compartment (the airintaking branch pipe is removed)  – the C14NZ model

1 – information plate;
2 – casing of the air filter;
3 – casing of the top fastening of a rack of a suspension bracket;
4 – a tank of the washing liquid;
5 – tank of brake fluid;
6 – generator;
7 – accelerator rope;
8 – steering drafts;
9 – electronic control unit
vsprysky fuels;
10 – broad tank;
11 – coupling switching off drive rope;

12 – ignition coil;
13 – wire of the plus plug of the accumulator;
14 – wire of the minus plug of the accumulator;
15 – indicator of a condition of the accumulator;
16 – ignition distributor
17 – radiator;
18 – cooling fan;
19 – the probe for check of level of oil;
20 – cap of a jellied mouth of oil;
21 – oxygen sensor;
22 – tube of supply of hot air

Arrangement of elements in a motive compartment  – the C14CE model


1 – information plate;
2 – casing of the air filter;
3 – casing of the top fastening of a rack of a suspension bracket;
4 – a tank of the washing liquid;
5 – tank of brake fluid;
6 – throttle case;
7 – inlet collector;
8 – steering drafts;
9 – accelerator rope;
10 – broad tank;
11 – coupling switching off drive rope;
12 – wire of the plus plug of the accumulator;
13 – wire of the minus plug of the accumulator;
14 – indicator of a condition of the accumulator;
15 – tank of system of hydrostrengthening of steering;
16 – ignition coil;
17 – radiator;
18 – cooling fan;
19 – the probe for check of level of oil;
20 – cap of a jellied mouth of oil;
21 – injectors;
22 – fuel collector

Arrangement of elements in a motive compartment  – the S2HE model

1 – information plate;
2 – casing of the air filter;
3 – casing of the top fastening of a rack of a suspension bracket;
4 – a tank of the washing liquid of wind glass / back glass;
5 – tank of brake fluid;
6 – air stream sensor;
7 – airintaking branch pipe;
8 – block of safety locks / relay;
9 – broad tank;
10 – a tank of the washing liquid of headlights of head light;
11 – ABS hydraulic modulator;
12 – ignition coil;
13 – wire of the plus plug of the accumulator;
14 – wire of the minus plug of the accumulator;
15 – indicator of a condition of the accumulator;
16 – tank of system of hydrostrengthening of steering;
17 – distributor;
18 – radiator;
19 – the probe for check of level of oil;
20 – casing of spark plugs;
21 – accelerator rope;
22 – cap of a jellied mouth of oil

The bottom view of a motive compartment  – the C16SE model

1 – brake support;
2 – fixing nut of the stabilizer of cross stability;
3 – lower lever of a suspension bracket;
4 – catalytic converter;
5 – stretcher;
6 – tubes of system of hydrostrengthening
steering;
7 – oil filter;
8 – coupling casing;
9 – differential casing;
10 – cap of a drain opening of an oil case;
11 – half shaft;
12 – nuts of back fastening of the engine / transmission to a stretcher;
13 – connection of exhaust pipes

Bottom view of a back part of the car

1 – shock-absorber;
2 – muffler;
3 – tube of a jellied mouth of the fuel tank;
4 – the torsion beam;
5 – fuel filter;
6 – fuel tank;
7 – strips of fastening of the fuel tank;
8 – rope of the emergency brake;
9 – spring;
10 – longitudinal lever of a suspension bracket

On the homepage